Material Safety Data Sheet
| GOLDEN STAR INC. |
Revision Date: 9-19-97 |
| 400 E. 10th Avenue |
Revised by Donald Parker |
| North Kansas City, MO 64116 |
The following is true and correct to the |
| Phone: (816) 842-0233 |
best of my knowledge. |
| Fax: (816) 842-1129 |
Donald Parker, Compliance Officer, Golden Star Inc. |
EMERGENCY NUMBER:
1-800-821-2792
page 1 of 3 pages
| HAZARD |
RATINGS |
| 0 = Least |
Health = 1 |
| 1 = Slight |
Fire = 1 |
| 2 = Moderate |
Reactivity = 0 |
| 3 = High |
Equipment = A |
| 4 = Extreme |
|
SECTION
I: PRODUCT DESCRIPTION
| Product Name: |
STAINLESS STEEL POLISH |
| Product Number: |
CPL-11 |
| Product Class: |
POLISH |
_____________________________________________
SECTION II: PRODUCT COMPOSITION
Occupation
Exposure Limits
| Ingredient |
Percent |
Cas# |
TLV(mg/CuM) |
PEL(mg/CuM) |
| Aliphatic Petroleum Distillate |
80% |
64742-06-9 |
5 as Mist |
5 as Mist |
| Paraffinic Petroleum Distillate |
11% |
64742-65-0 |
5 as Mist |
5 as Mist |
| Alliphatic Petroleum Distillate |
6% |
64742-89-8 |
1350 |
1350 |
| Amyl Acetate |
1% |
628637 |
530 |
530 |
_____________________________________________
SECTION III: PHYSICAL
PROPERTIES
| Boiling Range: |
251-328°C / 484-622°F |
| Specific Gravity (Water = 1): |
0.812 |
| Vapor Pressure at 20°C (MM of HG): |
<0.05 |
| Vapor Density (Air = 1): |
8 |
| Solubility in Water: |
Negligible |
| Evaporation Rate: |
<0.01 |
| % Volatiles: |
Nil |
| Appearance and Odor: |
Clear Liquid; Mild Odor |
_____________________________________________
SECTION IV: FIRE AND EXPLOSION DATA
| Lower Flammability Limits (% in air): |
1.0 |
| Flash Point (and Method): |
270°F (PMCC) |
| Flammability Classification: |
l l l B |
| Recommended Extinguishing Media: |
NFPA Class B Extinguisher (Carbon dioxide, alcohol foam or dry chemical) |
Special Fire Fighting
Procedures: Water spray may be ineffective on fire but
can protect
firefighters and cool closed containers. Use fog nozzles if
water is used. Use air supplied
breathing masks.
Unusual Fire/Explosion Hazards: Keep
away from heat and open flame. Closed container may
explode if exposed to extreme heat.
_____________________________________________
SECTION V: HEALTH
INFORMATION
| Threshold Limit Value: |
5 MG/M3 (Oil Mist) |
| OSHA PEL: |
5 MG/M3 (Oil Mist) |
| Acute Toxicity: |
Expected to be approximately 1.0-1.5 GR/KG (Oral LD50,RAT) |
| Effects of Overexposure: |
Contact with eyes and skin can cause irritation |
| Emergency First Aid Procedures: |
|
| ----------Eye Contact: |
Flush with water for 15 minutes. Get medical
attention. |
| ----------Skin Contact: |
Remove contaminated clothing and shoes. Wash exposed areas with
soap and water. If irritation persists, get medical attention. |
| ----------Inhalation: |
Remove to fresh air. If discomfort persists, get medical attention. |
| ----------Ingestion: |
Call physician immediately. Do not induce vomiting. |
| |
|
| ****WARNING: |
This product contains traces, yet detectable amounts, of a chemical known to the state of
California to cause cancer/birth defects or other reproductive harm. |
_____________________________________________
SECTION VI: REACTIVITY DATA
| Stability: |
Stable |
| Conditions to Avoid: |
Extreme heat and open flame |
| Incompatibility with other Materials: |
Strong oxidizers such as permanganate |
| Hazardous Decomposition Products: |
Carbon monoxide from burning |
| Hazardous Polymerization |
Will not occur |
_____________________________________________
SECTION VII: FIRE AND SPILL/LEAK PROCEDURES
| In Case of Fire: |
Use water spray, CO2, dry chemical or foam |
| Procedures if Material is Spilled or Released: |
Isolate from sources of ignition. Absorb on inert media and containerize. |
| Waste Disposal Procedures |
Incinerate per local, state and federal pollution regulations. |
_____________________________________________
SECTION VIII: SPECIAL PROTECTION INFORMATION:
| Respiratory Protection: |
Use NIOSH approved breathing mask where spray mist is encountered |
| Local Exhaust: |
Preferable |
| Protective Gloves: |
Solvent resistant rubber, vinyl or neoprene |
| Eye Protection: |
Chemical safety goggles |
| Other Protective Equipment: |
Eye wash; Safety shower; Protective clothing |
_____________________________________________
SECTION IX: ADDITIONAL PRECAUTIONS
Keep away from heat,
sparks, and open flame.
Avoid prolonged breathing of vapor or spray mist.
Keep container closed when not in use.
Empty container is hazardous.
Store large amounts in structures made for combustible
liquids.
Use only with adequate ventilation.
Do not store above 49°C (120°F)
Continue all label precautions.
Do not cut, braze or weld container.
The information herein is
presented in good faith and believed to be correct as of the
hereof. However, Golden Star makes no representation as to
the completeness and
accuracy thereof. Users must make their own determination as
to the suitability of the
product for their purposes prior to use.
No representations or warranties, either expressed or
implied, of merchantability, fitness
for a particular purpose or of any other nature with respect
to the product or to the
information herein is made hereunder. Golden Star shall in no
event be responsible
for any damages of whatsoever nature directly or indirectly
resulting from the
publication or use of or reliance upon information contained
herein.
|